C 9L AAS S
30 AMP PC or FLANGE MOUNT MINIATURE RELAY
SPECIFICATIONS CLASS 9A
TEMPERATURE
Operating:
COIL
Pull-in Voltage:
75% of Nominal Voltage or Less
10% of Nominal voltage or More
120% Max.
-55˚C to +85˚C
-55˚C to +130˚C
Storage:
Dropout voltage:
Max. coil voltage:
Power consumption:
Duty:
Insulation System:
Coil Resistance
2.8 Watts max.
VIBRATION RESISTANCE
Continuous
Functional:
10 to 55Hz 1.65 mm
max.No contact opening 1>00 uS
Class "F" (155˚C)
±10% Measured @ 25˚C
SHOCK RESISTANCE
Functional:
CONTACT
10 g's for 11 mS, No contact Opening
> 100 µS
100 g's
SPST-N.O., SPDT
Contact Configuration:
Contact Material:
Silver Cadmium Oxide
277 VAC, 28VDC max.
75 Milliohms @ 1 min, rated current
(switched)
Mechanical:
Switching voltage:
Contact Resistance:
LIFE
Electrical (Rated Load)
Mechanical (No Load):
100,000 Operations
10 million Operations Typical
1A, 5VDC, 12VAC
Minimum Load:
MISCELLANEOUS
Operating Position:
Enclosure:
TIMING
DC:15 mS typ. including bounce
DC:15mS typ. including bounce
Any
Operate Time:
Release Time:
Epoxy sealed immersion cleanable
suitable for automatic circuit board
processing. Max. exposure soldering
temperature is 4 sec.@ 500˚F.
94V-O Flammability rating.
1/4" Q.C. & safety wells accept insulated
Female Q.C. terminals.
DIELECTRIC STRENGTH
Between Open Contacts:
Contacts to coil:
1500 V rms
2500V rms
1000 mΩ min. @ 500 VDC, 25˚C 50% RH
Enclosure:
Terminals:
Insulation Resistance
Weight:
33 Grams, 1.2 oz approx.
CONTACT RATINGS
Meets UL 508, UL 873 and UL 1950 - 1/8" thru air - 1/4" over surface (See Foot notes)
AC Measured @ 50/60Hz
SPDT
SPST
LOAD
VOLTAGE
OPERATIONS
RATING
N.O.
N.C.
N.O.
N.C.
100,000
100,000
100,000
100,000
1,000
20A
20A
20A
-
1 HP
2 HP
-
30/80A
TV-5
10A
10A
†15A
10A
-
1/4 HP
1/2 HP
-
12/30A
-
3A
GENERAL PURPOSE
RESISTIVE
240 VAC
240 VAC
28 VDC
30A
20A
20A
25A
1 HP
2 HP
22/98A
30/80A
TV-5
*15A
†15A
10A
-
1/4 HP
1/2 HP
-
12/30A
-
3A
RESISTIVE HEATER ††
MOTOR (HP)
240 VAC
125 VAC
240 VAC
120 VAC
240 VAC
240 VAC
277 VAC
240 VAC
1,000
MOTOR
30,000
30,000
25,000
6,000
FLA/LRA ‡
TUNGSTEN
BALLAST
PILOT DUTY
10A
470 VA
470 VA
275 VA
275 VA
6,000
*
15 Amp general purpose rating on SPST-NC contact valid only under UL 508 column B spacings and UL
873 columns B, C & D spacings. Derate to 10 Amps when used under UL 873 columns E & F spacings
and UL 1950.
†
15 Amp resistive rating on SPST-NC contacts and SPDT contacts (Normally closed side only) valid only
under UL 873 columns E & F spacings. Derate to 10 Amps when used under UL 508 Column B spacings,
under UL 873 columns B, C & D spacings and UL 1950.
†† The resistance heater rating is not a discreet UL heater rating but is a valid UL rating that is derived
from the UL general purpose category in the above table of contact ratings.
‡
FLA = Full load Amps, LRA = Locked rotor Amps.
Coil measured @ 25˚ C
PART NUMBERS
SPDT
30AMP
FLANGE MT.
FIGURE "B"
SPST-NO
30AMP
P.C. MT.
SPDT
30AMP
P.C. MT.
SPST-NO
30AMP-
FLANGE MT.
FIGURE "B"
NOMINAL
INPUT
VOLTAGE
NOMINAL
RESIS-
TANCE
(Ohms)
NOMINAL
POWER
(Watts)
FIGURE "A" FIGURE "A"
DC OPERATED COIL
W9AS1D22-5
W9ASID22-12
W9ASID22-24
W9ASID22-48
W9ASID22-110
W9AS5D22-5 W9AS1D52-5
W9AS5D22-12 W9ASID52-12
W9AS5D22-24 W9ASID52-24
W9AS5D22-48 W9ASID52-48
W9AS5D22-110 W9ASID52-110
W9AS5D52-5
W9AS5D52-12
W9AS5D52-24
W9AS5D52-48
5
25
144
576
2,304
12,100
1W
1W
1W
1W
1W
12
24
48
W9AS5D52-110 110
PART NUMBERS SHOWN ALSO AVAILABLE THRU STOCKING DISTRIBUTION.
WEBSITE: www.magnecraft.com - EMAIL:info@magnecraft.com - FAX ON DEMAND 1-800/891-2957 - DOCUMENT 100
PAGE 50
ETC [ ETC ]
